Recent content by Rake12

Direct from AA

I am talking about the Aftermarket Assisan kit.AA

Anyone that installed the AA clutch kit should definitely check out this form I am involved in, a lot of good info about the kit and the problems we are having with it. The weights are sticking and could cause serious problems in your clutch...

Well I doubt it is clutch sticking with that little mileage. I say you have it in the right place the dealer has the equipment for that. Just thought I would mention the clutch just in case.

HOW Many miles ? If it has any amount of miles on it, if it were me I would tell them to clean the clutches. They are known if dirty they could stick some. Just a thought may not be it, but it is there now so may be worth getting it done.

Changed my kit to a different AA setup more on the performance setup. Huge difference from the Cruiser setup I used first, way more power and more speed on top end.With this setup you don't drop much RPM maybe 400rpms. but way more pull especially off the line. The only issue I have is the belt...

Yep good video and not a bad job at all

Yep wasn't bad AA has a video shows exactly how to do it. I ACTUALLY took the secondary apart as well and removed one thin shim made the belt ride a bit higher in secondary.No special tools needed for the primary clutch. Now if you do anything with the secondary you will need a clutch spring...

I installed the AA clutch kit, no more jerky throttle. It is the clutch ramp causing the issue. It has a high spot that it has to climb over on engagement, causing the issue, mine is smooth as silk now.

Mine was the relay at the battery only did it when real cold out Hasn't done it since I keep it in heated garage. When cold the relay wasn't closing and no power coming out of the switch to power the accessories.

They all seem to surge when pulling away if that is what you are talking about

Put the kit in and used the cruiser set up only went for shot drive up the road RPMS were way down and I did notice a difference in power . This set up is smooth but not quite as snappy in midrange. I will be playing with the set up to try and get a little more power and still try to keep the...

Thanks did tighten all but will double check again make sure I didn't miss any

Just wondering if anyone has had any electrical issues? Started my XR at camp all ok but my back up light, by light bar ,my stereo, and winch wouldn't work. The illumination lights on the switches were very dim. When I touched the winch switch the illumination lights went out. A minute later...